CN63500-R1-AL2美国OMEGA CN63500-R1-AL2
CN63500-R1-AL2
1/16 DIN上限/下限控制器
CN63500 Series
2年保修 新产品! CE
1/16 DIN上限/下限控制器
CN63500 Series:1/16 DIN上限/下限控制器
双四位LED显示
热电偶或热电阻传感器输入
远程复位输入
主要的限制输出：5个继电器，可选择为高或低的旅行的活化
5个继电器报警（可选）
可选的NEMA 4X（IP65）密封的前面板
通过可编程参数**关闭
双重显示
该cn63500系列极限温度控制器，旨在提供一个独立的关闭热过程。该cn63500接受各种温度传感器的信号（热电偶或热电阻元件），其综合规划使它能够满足各种应用的要求。双4位数字显示器可以观看过程中的温度和设定的同时。前面板指示通知的过程和状态输出操作符。主要的限制输出和报警输出，可现场更换。极限输出可选高或低的活化。如果过程温度超过一个高的旅行限制，或低于低的旅行限制，限制继电器断电启动一个进程关闭。极限输出不能被复位到温度恢复到适当的经营范围的过程；手动复位是必需的（本地或远程）。传感器故障，将启动一个进程关闭。继电器报警（S）可配置为启动根据各种动作（**的高或低，偏差高或低，或可调的滞后带）。备用功能抑制报警在电源装置的工艺稳定的报警区域之外。单位建造轻便，用彩色面板高冲击塑料盒。前面板符合NEMA 4X（IP65）规范正确安装时。多个单位可以水平或垂直堆叠。现代表面贴装技术，广泛的测试，豪华的高抗噪声干扰使cn63500在工业环境中非常可靠。
规格：
Display: 2-line by 4-digit LED
Upper (Main) Display: 10.2 mm (0.4") H red LED
Lower (Secondary) Display: 7.6 mm (0.3") H green LED
Power:
Line Voltage Models: 85 to 250 Vac, 50/60 Hz, 8 VA
Low-Voltage Models:
DC Power: 18 to 36 Vdc,7W
AC Power: 24 Vac ±10%, 50/60 Hz, 9 VA
Memory: Non-volatile E2PROM retains all programmable parameters and values
Environmental Conditions
Operating Range: FM rated @ 0 to 65°C, UL rated @ 0 to 55°C
Storage Range: -40 to 80°C (-40 to 176°F)
Operating and Storage Humidity: 85% max relative humidity (non-condensing) from 0°C to 65°C (32 x 149°F)
Altitude: Up to 2000 m
Isolation Breakdown Ratings
AC Line With Respect to All Inputs and Outputs: 2300 V for 1 minute (250 V working)
Relay Contacts to All Other Inputs and Outputs: 2300 Vac
DC Power With Respect to Sensor Input: 50 V working (500 V for 1 minute)
Connection: Wire clamping screw terminals
Weight: 0.17 kg (0.38 lb)
Input Specifications
Sensor Input
Sample Period: 100 ms
Step Response Time: Less than 300 ms typical, 400 ms max (to within 99% of final value)
Normal Mode Rejection: >40 dB @ 50/60 Hz
Common Mode Rejection: >120 dB, DC to 60 Hz
Overvoltage Protection: Input overload 120 Vac for 15 s max
Failed Sensor Response:
Main Output: Sensor failure will initiate a process shutdown
Display: "OPEN"
Alarms: Upscale
Indication Accuracy: ±(0.3% of span +1°C) @ 23°C ambient after 20 minute warm-up (includes NIST conformity, cold-junction effect, A/D conversion errors and linearization conformity
Span Drift (Maximum): 130 PPM/°C
Rtd Input: 2- or 3-wire, 100 ù platinum, alpha = 0.00385 (DIN43760), alpha = 0.0039162
Excitation: 150 A typical
Lead Resistance: 15 Ω max per input lead
Remote Resent Input: Internally pulled up to 5 Vdc 1 mΩ
VIL: 0.85 V max
VIH: 3.65 V min
VIN Max: 5.25 Vdc
IOFF:1 μA max
Output Specifications
Limit and Alarm Output Relays
Contact Rating: 5 A @ 250 Vac or 30 Vdc (resistive load) 1/10 HP @ 120 Vac (inductive load)
Life Expectancy: 100,000 cycles at max load rating (decreasing load increases life expectancy)
Limit Output:
CN63500-R1-AL1: Form "C" relay
CN63500-R1-AL2: Form "A" relay
Selectable for high or low trip activation, if the process temperature goes above the limit setpoint for a high trip, or below the limit setpoint for a low trip, the limit relay will deenergize to initiate a process shutdown; the limit output cannot be reset until the process temperature returns to the proper operating range; manual reset is required (local or remote)
AlarmOutputs: 1 or 2 form "A" relays
Modes: Absolute high-acting, absolute low-acting, deviation high-acting, deviation low-acting, inside band-acting, outside band-acting
Reset Action: programmable, automatic or latched; latched alarms can be reset regardless of limit exceed condition
Standby Mode: Programmable, enable or disable
Hysteresis: Programmable
Thermocouple Inputs
Types: T, E, J, K, R, S, B, N, linear mV, software selectable
Input Impedance: 20 MΩ, all types
Lead Resistance Effect: 0.25 μV/Ω
Cold-Junction Compensation: <±1°C typical, (±1.5°C max), error over 0 to 65°C (32 to 149°F) max ambient temperature range; defeated for linear mV indication mode
Resolution: 1° for all types, or 0.1° for T, E, J, K, and N only
Thermocouple
Type
|
Display
Range
|
Wire Color
|
|
ANSI
|
BS1843
|
|
T
|
-200 to 400°C
-328 to 752°F
|
(+) Blue
(-) Red
|
(+) White
(-) Blue
|
|
E
|
-200 to 750°C
-328 to 1382°F
|
(+) Violet
(-) Red
|
(+) Brown
(-) Blue
|
|
J
|
-200 to 760°C
-328 to1400°F
|
(+) White
(-) Red
|
(+) Yellow
(-) Blue
|
|
K
|
-200 to 1250°C
-328 to 2282°F
|
(+) Yellow
(-) Red
|
(+) Brown
(-) Blue
|
|
R
|
0 to 1768°C
32 to 3214°F
|
(+) Black
(-) Red
|
(+) White
(-) Blue
|
|
S
|
0 to 1768°C
32 to 3214°F
|
(+) Black
(-) Red
|
(+) White
(-) Blue
|
|
B
|
149 to 1820°C
300 to 3308°F
|
(+)Grey
(-)Red
|
No standard
|
|
N
|
-200 to 1300°C
-328 to 2372°F
|
(+) Orange
(-) Red
|
(+) Orange
(-) Blue
|
|
mV
|
-5.00 to 56.00mV
|
No standard
|
No standard
|
|
|
|
|
RTD Type
|
Range
|
|
385
|
-200 to 600°C (-328 to 1100°F)
|
|
392
|
-200 to 600°C (-328 to 1100°F)
|
|
Ω
|
2.0 to 320.0Ω
|
|
产品型号 产品描述
Standard Power Models (85 to 250 Vac, 50 to 60Hz)
CN63500-R1-AL2 Single output, form "A" relay, 2 alarms
Low-Voltage Models (18 to 36 Vdc)
CN63500-R1-AL1-LV Single output, form "C", 1 alarm
CN63500-R1-AL2-LV Single output form "A" relay, 2 alarms
CN63500-R1-AL2-4X Single output form "A" relay, 2 alarms, NEMA 4X cover.
Accessories
CN6-RBDLA210 Output module, single-output, form "C" relay, 1 alarm
CN6-48111 Output module, single-output, form "A" relay, 2 alarms
CN63500-R1-AL2
CN63500-R1-AL2美国OMEGA CN63500-R1-AL2相关产品
